Synthesis of Chitosan, Carboxymethyl Cellulose, and Silica Membrane for Seawater Desalination as a Clean Water Source
DOI:
https://doi.org/10.69930/fsst.v3i1.767Keywords:
Membrane; Chitosan; Carboxymethyl Cellulose; Silica; DesalinationAbstract
This research is driven by the high salinity of seawater, which limits its use as a clean water source, necessitating eco-friendly desalination technology,. The objective was to synthesize a composite membrane based on chitosan (CS), carboxymethyl cellulose (CMC), and silica (SiO₂) and evaluate its effectiveness in seawater desalination,. The research employed a solution casting technique using 0.15 g chitosan, 0.05 g CMC, and 0.05 g silica, which were mixed homogeneously and dried at room temperature,. The results showed successful membrane formation with Si–O–Si and Si–O–C chemical bonds and electrostatic interactions between the polymers,. SEM analysis revealed a relatively homogeneous surface, while EDX confirmed a silicon composition of 2.23%,,. Desalination tests demonstrated a drastic reduction in TDS from 38,000 mg/L to meet clean water standards, with salinity dropping to 3.138 ppt and a stable pH of 7.8,. It is concluded that the CS-CMC/SiO₂ composite membrane is an effective and sustainable solution for seawater desalination in accordance with Permenkes No. 2 of 2023.
References
Ahmadizadegan, H. (2020). Polyester/SiO2 Nanocomposites: Gas Permeation, Mechanical, Thermal and Morphological Study of Membranes. Iranian Journal of Chemistry & Chemical Engineering-International English Edition, 39(2), 33–47.
Anawai, A., Rahmi, Anas, M., & Erniwati. (2023). Silika Sebagai Material Penukar Ion pada Elektroda CDI: Efek Ketebalan Terhadap Kapasitansi dan Kemampuan Desalinasi. Resistor: Jurnal Pendidikan Vokasional Teknik, 1(2), 63–72.
He, X., Xu, H., & Li, H. (2015). Cr (VI) Removal from Aqueous Solution by Chitosan / Carboxylmethyl Cellulose / Silica Hybrid Membrane. Journal of Chemical and Pharmaceutical Research, 7(10), 234–240.
Islam, M. R., Lin, B., Yu, Y., Chen, C. C., & Malmali, M. (2023). Comparative Energetics of Various Membrane Distillation Configurations and Guidelines for Design and Operation. Membranes, 13(3).
Ismillayli, N., Andayani, I. G. A. S., Honiar, R., Mariana, B., Sanjaya, R. K., & Hermanto. (2020). Polyelectrolyte Complex (PEC) film based on chitosan as potential edible films and their antibacterial activity test. IOP Conference Series: Materials Science and Engineering, 959(1).
Malis, E., Ridho, R., Findari, H., & Ardiyansyah, F. (2022). Pembuatan dan Karakterisasi Membran Komposit Kitosan/Montmorilonit-Glutaraldehid/Kitosan (CS/MMG-GA) dan Aplikasinya dalam Fuel Cell. Jurnal Crystal: Publikasi Penelitian Kimia dan Terapannya, 4(2), 37–74.
Maro, R. S., Samin, M., & Pamungkas, B. T. T. (2023). Analisis Laju Jumlah Penduduk Terhadap Ketersediaan Air Bersih Untuk Pemenuhan Kebutuhan Rumah Tangga Di Desa Lakat Kecamatan Kuatnana Kabupaten Timor Tengah Selatan. Jurnal Geografi, 19(1), 104–117.
Muljani, S., Kusuma, K. A., Nofitasari, L., Amalia, A. R., & Hapsari, N. (2018). Sintesis membran kitosan silika dari geothermal sludge. Jurnal Teknik Kimia, 13(1), 22–26.
Permenkes No. 2 Tahun 2023. (2023). Peraturan Menteri Kesehatan Republik Indonesia Nomor 2 Tahun 2023 tentang Peraturan Pelaksanaan Peraturan Pemerintah Nomor 66 Tahun 2014 tentang Kesehatan Lingkungan. Kementerian Kesehatan Republik Indonesia.
Shokri, A., & Fard, M. S. (2023). Techno-economic assessment of water desalination: Future outlooks and challenges. Process Safety and Environmental Protection, 169, 564-578 (Informasi dari percakapan sebelumnya).
Spoială, A., Ilie, C. I., Ficai, D., Ficai, A., & Andronescu, E. (2021). Chitosan-based nanocomposite polymeric membranes for water purification—a review. Materials, 14(9), 1–29.
Sulistyawati, E., Anggarawati, H., Rochmah, N., & Ariardini, N. (2022). Isoterm dan Termodinamika Adsorpsi Mikrokapsul Kitosan Tertaut Silang Kalium Persulfat Terhadap Zat Warna Methyl Orange. Jurnal Eksergi, 19(2), 51–57.
